TFT-LCD器件Al电极TFT特性研究

张家祥; 王彦强; 卢凯; 张文余; 王凤涛; 冀新友; 王亮; 张洁; 王琪; 刘琨; 李良杰; 李京鹏

doi:10.3788/YJYXS20173206.0433

您当前的位置：

首页 >

文章列表页 >

TFT-LCD器件Al电极TFT特性研究

器件技术 | 更新时间：2020-07-07

- TFT-LCD器件Al电极TFT特性研究
- TFT character of Al electrode in TFT-LCD
- 液晶与显示 2017年32卷第6期页码：433-437
- 作者机构：
  
  北京京东方光电科技有限公司, 北京 100176
- 作者简介：
  
  [ "张家祥(1985-), 男, 山东滨州人, 硕士, 工程师, 主要从事与液晶面板相关的技术研发工作。E-mail:zhangjiaxiang@boe.com.cn" ]
- 基金信息：
- DOI：10.3788/YJYXS20173206.0433
  中图分类号： TN141.9
- 收稿日期：2016-12-19，
  
  录用日期：2017-1-8，
  
  纸质出版日期：2017-06-05
- 稿件说明：
移动端阅览
张家祥, 王彦强, 卢凯, 等. TFT-LCD器件Al电极TFT特性研究[J]. 液晶与显示, 2017,32(6):433-437.

Jia-xiang ZHANG, Yan-qiang WANG, Kai LU, et al. TFT character of Al electrode in TFT-LCD[J]. Chinese journal of liquid crystals and displays, 2017, 32(6): 433-437.
张家祥, 王彦强, 卢凯, 等. TFT-LCD器件Al电极TFT特性研究[J]. 液晶与显示, 2017,32(6):433-437. DOI： 10.3788/YJYXS20173206.0433.

Jia-xiang ZHANG, Yan-qiang WANG, Kai LU, et al. TFT character of Al electrode in TFT-LCD[J]. Chinese journal of liquid crystals and displays, 2017, 32(6): 433-437. DOI： 10.3788/YJYXS20173206.0433.

摘要

本文对Mo/Al/Mo作为TFT-LCD器件源/漏极的TFT特性进行了研究。与单层Mo相比，存在沟道界面粗糙，

off

偏大问题，通过优化膜层结构，改善界面状态，得到了平整的沟道界面和良好的TFT特性。增加Bottom Mo的厚度，可以有效减少Al的渗透，防止Al-Si化合物的形成，得到界面平整的沟道；N

刻蚀后SF

处理对特性影响不大，增加刻蚀时间可以使

和

off

同时降低；PVX沉积前处理气体N

+NH

与H

区别不大，都可以减少沟道缺陷，而增加H

处理时间会增强等离子的轰击作用，减少了沟道表面Al-Si化合物，但处理时间过长可能会使沟道缺陷增加；采用bottom Mo加厚，N

刻蚀以及PVX沉积前处理等最优条件，可以得到沟道界面良好，TFT特性与单层Mo相当的TFT器件。

Abstract

TFT character of the Mo/Al/Mo as TFT-LCD source/drain was studied. Compared with the single Mo

the channel interface was rougher and

off

was larger. Through the optimization of the structure of membrane layer and the interface state

good TFT character and smooth channel interface were received. Increasing the thickness of bottom Mo could effectively reduce the penetration of Al

and prevent the formation of Al-Si compounds to get the smooth channel interface. SF

treatment after N

etching had no influence on properties

while

and

off

were all reduced with increasing of the etching time. The treatment gas H

before PVX deposition the same as N

+NH

could reduce the channel defects. The plasma bombardment effect was enhanced and Al-Si compounds on the surface of the channel were reduced when the H

processing time was increased

but the processing time was not too long to increase channel defect. Using the best condition of bottom Mo thickening

the N

etch time increasing and the plasma treatment before PVX deposition

the good channel interface could be obtained and TFT character was as well as that of single Mo.

关键词

Keywords

references

孙杨, 张永栋, 朱燕林.单层ITO多点电容触摸屏的设计[J].液晶与显示, 2010, 25(4):551-553.

SUN Y, ZHANG Y D, ZHU Y L. Design of single layer ITO capacitive touch panel [J]. Chinese Journal of Liquid Crystals and Displays, 2010, 25(4): 551-553. (in Chinese)

谷至华.薄膜晶体管(TFT)阵列制造技术[M].上海:复旦大学出版社, 2007.

GU Z H.Thin Film Transistor (TFT) Array Manufacturing Techniques [M]. Shanghai: Fudan University Press, 2007. (in Chinese)

LAADES A, BLECH M, BÄHR M, et al. Comprehensive investigation of silicon surface passivation by a -Si:H and a -SiN x :H films [J]. Physica Status Solidi C, 2011, 8(3): 763-766.

LETERRIER Y, MÉDICO L, MÅNSON J A E. Mechanical integrity of transparent conductive oxide films for flexible polymer-based displays [J]. Thin Solid Films, 2004, 460(1/2): 156-166.

刘翔, 陈旭, 谢振宇, 等.使用低电阻金属铝制造薄膜晶体管阵列信号电极[J].液晶与显示, 2009, 24(4):533-536.

LIU X, CHEN X, XIE Z Y, et al. Low resistant metal for thin film transistors [J]. Chinese Journal of Liquid Crystals and Displays, 2009, 24(4): 533-536. (in Chinese)

赵颖, 熊绍珍, 孟志国, 等. H处理对a-Si TFT矩阵性能的改善作用[J].半导体学报, 1997, 18(1):58-60.

ZHAO Y, XIONG S Z, MENG Z G, et al. Improvement of characteristics of a-Si TFT matrix by H treatment [J]. Chinese Journal of Semiconductors, 1997, 18(1): 58-60. (in Chinese)

JANGH K, LEE C E, NOH S J. Poly-Si thin film transistors with a source overlap and a drain offset: leakage current characteristics [J]. Thin Solid Films, 1999, 341(1/2): 148-151.

浏览量

114

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

a-Si剩余膜厚对TFT特性的影响