光配向PI固烤时间与曝光能量对LCD光学及残影的影响

周学芹; 杨丽; 刘政明; 林熙乾

doi:10.3788/YJYXS20173208.0596

您当前的位置：

首页 >

文章列表页 >

光配向PI固烤时间与曝光能量对LCD光学及残影的影响

材料科学 | 更新时间：2020-08-12

- 光配向PI固烤时间与曝光能量对LCD光学及残影的影响
- Effects of PI post-bake time and UV dosage on LCD optical performance and image sticking by photo-alignment
- 液晶与显示 2017年32卷第8期页码：596-600
- 作者机构：
  
  昆山龙腾光电有限公司, 江苏昆山 215301
- 作者简介：
  
  [ "周学芹(1990-), 女, 江苏宿迁人, 硕士研究生, 工程师, 2016年于常州大学获得硕士学位, 主要从事TFT-LCD方面的研究。E-mail: cczuzxq@126.com" ]
- 基金信息：
- DOI：10.3788/YJYXS20173208.0596
  中图分类号： TN141.9
- 收稿日期：2016-12-17，
  
  录用日期：2017-1-22，
  
  纸质出版日期：2017-08-05
- 稿件说明：
移动端阅览
周学芹, 杨丽, 刘政明, 等. 光配向PI固烤时间与曝光能量对LCD光学及残影的影响[J]. 液晶与显示, 2017,32(8):596-600.

Xue-qin ZHOU, Li YANG, Zheng-ming LIU, et al. Effects of PI post-bake time and UV dosage on LCD optical performance and image sticking by photo-alignment[J]. Chinese journal of liquid crystals and displays, 2017, 32(8): 596-600.
周学芹, 杨丽, 刘政明, 等. 光配向PI固烤时间与曝光能量对LCD光学及残影的影响[J]. 液晶与显示, 2017,32(8):596-600. DOI： 10.3788/YJYXS20173208.0596.

Xue-qin ZHOU, Li YANG, Zheng-ming LIU, et al. Effects of PI post-bake time and UV dosage on LCD optical performance and image sticking by photo-alignment[J]. Chinese journal of liquid crystals and displays, 2017, 32(8): 596-600. DOI： 10.3788/YJYXS20173208.0596.

摘要

采用光配向技术使PI获得配向能力并制得IPS型LCD，通过AOI光学自动检测设备以及DMS光学测量系统对在不同PI固烤时间和UV曝光能量下获得样品的预倾角、对比度及穿透率进行了量测，并研究了各条件下样品的残影（Image Sticking）性能。结果显示：在900~2 700 s，400~600 mJ/cm

范围内，固烤时间和曝光能量对LCD光学性能影响较小，但对残影性能影响较大，IS随曝光量增大有恶化的趋势，且该趋势在高亚胺化程度下趋于平缓|调整固烤时间及曝光能量可以获得较佳的残影性能，固烤时间1 800 s，曝光能量400~500 mJ/cm

条件的LCD残影性能较佳。

Abstract

The alignment ability of polyimide was obtained by Photo-Alignment process

and then IPS type LCDs was prepared in the experiment. Pre-tilt angle

contrast ratio and transmittance of LCD samples prepared under different post-bake time and UV dosage were characterized by AOI (Automated Optical Inspection) and DMS LCD photoelectric measuring system. Besides

image sticking (IS) of all the conditions was studied. The results showed that the post-bake time and UV dosage ranged between 900~2 700 s and 400~600 mJ/cm

had little effect on optical performance and these two factors had obvious influence on IS. IS had a tendency to deteriorate with the increasing of UV Dosage

and the trend tended to be gentle under the condition of high imidization. Excellent IS performance could be obtained by adjusting the post-bake time and UV dosage. The LCD samples showed the best IS performance under the conditions of post-bake 1 800 s and UV dosage 400~500 mJ/cm

关键词

Keywords

references

范恒亮, 汤展峰, 刘利萍, 等. TFT-LCD残影不良的研究与改善[J].液晶与显示, 2016, 31(3):270-275.

FAN H L, TANG Z F, LIU L P, et al . Research and improvement of TFT-LCD image-retention[J]. Chinese Journal of Liquid Crystals and Displays , 2016, 31(3):270-275. (in Chinese)

REN W, HSIEH CC, ZHAO Y C, et al . The investigation of photo alignment polyimide material for large size IPS display[J]. SID Symposium Digest of Technical Papers , 2016, 47(1):1563-1565.

张春华, 杨正华, 丁孟贤.聚酰亚胺光控取向膜的研究现状[J].高分子通报, 2002(6):15-23.

ZHANG C H, YANG Z H, DING M X. Recent development inphotoalignment polyimide films[J]. Polymer Bulletin , 2002(6):15-23. (in Chinese)

SCHADT M. Photo alignment and patterning of liquid crystal polymer films and optical devices by side-chain photopolymers[J]. Molecular Crystals and Liquid Crystals , 2014, 594(1):11-20.

MUN B J, CHO J H, LEE J H, et al . High speed in-plane switching liquid crystal cell by using photo alignment method[J]. Molecular Crystals and Liquid Crystals , 2015, 613(1):167-173.

王文根, 李瑛, 绍明, 等.液晶显示器的快速响应技术[J].现代显示, 2006(4):45-48.

WANG W G, LI Y, SHAO M, et al . Fast response technologies for LCD[J]. Advanced Display , 2006(4):45-48. (in Chinese)

ZHAOY C, HSIEH C C, SONG Y J, et al . The transmittance study of the photo alignment FFS LC mode[J]. SID Symposium Digest of Technical Papers , 2015, 46(1):1608-1610.

范金强. PI成膜对液晶显示特性的作用[D]. 上海: 上海交通大学, 2014. http://cdmd.cnki.com.cn/Article/CDMD-10248-1015805721.htm

FAN J Q. The effect of polyimide film for liquid crystal display[D]. Shanghai:Shanghai Jiao Tong University, 2014. (in Chinese)

马群刚.TFT-LCD原理与设计[M].北京:电子工业出版社, 2011.

MA Q G. TFT-LCD Theory and Design[M]. Beijing:Publishing House of Electronics Industry, 2011. (in Chinese)

浏览量

125

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

TFT-LCD制程对低频横纹色差的影响及研究

空间遥感光谱仪器光学性能地面检测系统

配向膜材料与面残影的关联性研究