去润湿图案化制备TIPS-并五苯有机薄膜晶体管

冯翔; 林广庆; 张俊; 李曼菲; 邱龙臻

doi:10.3788/YJYXS20132803.0338

您当前的位置：

首页 >

文章列表页 >

去润湿图案化制备TIPS-并五苯有机薄膜晶体管

器件物理及器件制备技术 | 更新时间：2020-08-12

- 去润湿图案化制备TIPS-并五苯有机薄膜晶体管
- Wetting/Dewetting Patterned TIPS-Pentacene Organic Thin-Film Transistor
- 液晶与显示 2013年28卷第3期页码：338-343
- 作者机构：
  
  1. 合肥工业大学化学工程学院,安徽合肥,230009
  2. 合肥工业大学光电技术研究院特种显示技术教育部重点实验室,特种显示技术国家工程实验室, 现代显示技术省部共建国家重点实验室培育基地,安徽合肥,230009
- 作者简介：
- 基金信息：
  
  973"();计划前沿专项(No. 2012CB723406)();国家自然科学基金(No. 51103034, No. 61107014)()
- DOI：10.3788/YJYXS20132803.0338
  中图分类号： O753+.2
- 收稿日期：2013-01-15，
  
  修回日期：2013-01-31，
  
  网络出版日期：2013-02-25，
  
  纸质出版日期：2013-06-15
- 稿件说明：
移动端阅览
冯翔, 林广庆, 张俊, 李曼菲, 邱龙臻. 去润湿图案化制备TIPS-并五苯有机薄膜晶体管[J]. 液晶与显示, 2013,28(3): 338-343

FENG Xiang, LIN Guang-qing, ZHANG Jun, LI Man-fei, QIU Long-zhen. Wetting/Dewetting Patterned TIPS-Pentacene Organic Thin-Film Transistor[J]. , 2013,28(3): 338-343
冯翔, 林广庆, 张俊, 李曼菲, 邱龙臻. 去润湿图案化制备TIPS-并五苯有机薄膜晶体管[J]. 液晶与显示, 2013,28(3): 338-343 DOI： 10.3788/YJYXS20132803.0338.

FENG Xiang, LIN Guang-qing, ZHANG Jun, LI Man-fei, QIU Long-zhen. Wetting/Dewetting Patterned TIPS-Pentacene Organic Thin-Film Transistor[J]. , 2013,28(3): 338-343 DOI： 10.3788/YJYXS20132803.0338.

摘要

利用润湿/去润湿的方法配合旋涂工艺制备了图案化的TIPS-并五苯有机半导体薄膜

制备了顶接触有机薄膜晶体管(OTFTs)。金相显微镜观察发现

转速的选择对TIPS-并五苯薄膜结晶形貌的影响较大。在1 000~2 000 r/min转速下制备的薄膜完整性好

结晶区域较大;而转速增加到3 000 r/min后

难以获得完整的薄膜且晶粒尺寸变小。电学性能研究得到器件的输出曲线、转移曲线、开关电流比、阈值电压、场效应迁移率

发现结晶形貌好的器件具有更好的电学性能。1 000 r/min转速下制备OTFT器件最大场效应迁移率为5.1610

-2

cmV

-1

电流开关比为810

。

Abstract

Top-contact organic thin-film transistors array was prepared by slectively dewetting of 6

13-Bis(triisopropylsilylethynyl) pentacene (TIPS-Pentacene) solution. The optical microscope images showed that the morphology of TIPS-pentacene crystal was influenced by the rotation speed. The TIPS-pentacene thin-films prepared at 1 000~2 000 r/min had good connectivity and large crystal domains. As the rotation speed increased to 3 000 r/min

the patterned film became incomplete and the crystal domain size reduced. The output and transfer curve

on/off current ratio

threshold voltage and field-effect mobility of the device were obtained by electric measurements. The TIPS-pentacene OTFTs prepared at 1 000 r/min had a maximum field-effect mobility of up to 5.1610

-2

cmV

-1

and an on/off current ratio of 810

关键词

Keywords

references

Crone B, Dodabalapur A, Lin Y Y, et al. Large-scale complementary integrated circuits based on organic transistors [J]. Nature, 2000, 403 (6769) : 521-523.[2] Klauk H, Zschieschang U, Pflaum J, et al. Ultralow-power organic complementary circuits [J]. Nature, 2007, 445 (7129):745-748.[3] Sekitani T, Noguchi Y, Hata K, et al. A rubberlike stretchable active matrix using elastic conductors [J]. Science, 2008, 321 (5895) : 1468-1472.[4] DeLongchamp D M, Kline R J, Lin E K, et al. High carrier mobility polythiophene thin films: structure determination by experiment and theory [J]. Adv. Mater., 2007, 19 (6):833-837.[5] Yan H, Chen Z H, Zheng Y, et al. A high-mobility electron-transporting polymer for printed transistors [J]. Nature, 2009, 457(7230):679-686.[6] Cho J H, Lee J, Xia Y, et al. Printable ion-gel gate dielectrics for low-voltage polymer thin-film transistors on plastic [J]. Nat. Mater., 2008, 7(11):900-906.[7] Tsao H N, Cho D M, Park I, et al. Ultrahigh mobility in polymer field-effect transistors by design [J]. J. Am. Chem. Soc., 2011, 133 (8):2605-2612.[8] Sun X N, Di C A, Liu Y Q. Engineering of the dielectric-semiconductor interface in organic field-effect transistors [J]. J. Mater. Chem., 2010, 20:2599-2611.[9] Smith J, Hamilton R, McCulloch I, et al. Solution-processed organic transistors based on semiconducting blends [J]. J. Mater. Chem., 2010, 20:2562-2574.[10] 曹进, 委福祥, 张晓波, 等. 加入激子阻挡层增强白色有机发光器件效率 [J]. 光电子·激光, 2005, 16(10):1171-1174.[11] Qiu L Z, Xu Q, Lee W H, et al. Organic thin-film transistors with a photo-patternable semiconducting polymer blend [J]. J. Mater. Chem., 2011, 21:15637-15642.[12] Choo B K, Choi J S, Kim G, et al. Self-organized process for patterning of a thin-film transistor [J]. J. Korean Phys. Soc., 2006, 48(6):1719-1722.[13] Horowitz G. Organic field-effect transistors [J]. Adv. Mate., 1998, 10(5):365-377.[14] Kitamura M, Imada T, Arakawa Y. Organic light-emitting diodes driven by pentacene-based thin-film transistors [J]. Appl. Phys. Lett., 2003, 83(16):3410-3412.[15] Choi D, Ahn B, Kim S H, et al. High-performance triisopropylsilylethynyl pentacene transistors via spin coating with a crystallization-assisting layer [J]. ACS Appl. Mater. Interfaces, 2012, (4):117-122.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

表面修饰制备高性能薄膜晶体管

石墨烯电极有机薄膜晶体管研究

基于量子点浮栅的有机透明存储器

基于三组分共轭聚合物的高灵敏度有机晶体管二氧化氮传感器

绝缘层等离子处理对有机薄膜晶体管突触性能的影响