掺杂及工艺条件对室温制备ZnO : Al性能的影响

任明放; 王 华; 许积文; 杨 玲

doi:null

您当前的位置：

首页 >

文章列表页 >

掺杂及工艺条件对室温制备ZnO : Al性能的影响

器件制备技术及器件物理 | 更新时间：2020-08-12

- 掺杂及工艺条件对室温制备ZnO : Al性能的影响
- Influence of Doping Content and Sputtering Parameter on Resistivity and Transmittancce of ZnO : Al Thin Films Prepared by DC Magnetron Sputtering at Room Temperature
- 液晶与显示 2009年24卷第1期页码：52-56
- 作者机构：
  
  1. 桂林电子科技大学信息材料科学与工程系, 广西桂林 541004, E-mail: wh65@guet.edu.cn
  2. 桂林电子科技大学广西信息材料重点实验室,广西桂林 541004
- 作者简介：
- 基金信息：
- DOI：
  中图分类号： O484
- 收稿日期：2008-08-04，
  
  修回日期：1900-01-02，
  
  网络出版日期：2009-02-20，
  
  纸质出版日期：2009-02-20
- 稿件说明：
移动端阅览
任明放;王华;许积文;杨玲. 掺杂及工艺条件对室温制备ZnO : Al性能的影响[J]. 液晶与显示, 2009,24(1): 52-56

REN Ming-fang;WANG Hua;XU Ji-wen;YANG Ling. Influence of Doping Content and Sputtering Parameter on Resistivity and Transmittancce of ZnO : Al Thin Films Prepared by DC Magnetron Sputtering at Room Temperature[J]. 液晶与显示, 2009,24(1): 52-56
任明放;王华;许积文;杨玲. 掺杂及工艺条件对室温制备ZnO : Al性能的影响[J]. 液晶与显示, 2009,24(1): 52-56 DOI：

REN Ming-fang;WANG Hua;XU Ji-wen;YANG Ling. Influence of Doping Content and Sputtering Parameter on Resistivity and Transmittancce of ZnO : Al Thin Films Prepared by DC Magnetron Sputtering at Room Temperature[J]. 液晶与显示, 2009,24(1): 52-56 DOI：

摘要

采用直流磁控溅射工艺

在室温条件下制备了ZnO : Al(ZAO)薄膜

研究了Al掺杂量和溅射工艺参数等对ZAO薄膜光电性能的影响。结果表明:Al掺杂量和溅射工艺参数均对薄膜的电阻率有显著影响

在Al掺杂质量分数为3%、溅射功率为100 W以及Ar压强为1.5 Pa的条件下

室温溅射淀积的ZAO薄膜可获得1.410

-3

cm的最小电阻率;Al掺杂量和工艺参数对薄膜的透光率均无明显的影响

薄膜的平均透光率在86~90％

但随Al掺杂量和溅射功率的增加

薄膜的截止吸收边均向短波长方向移动。对薄膜优值因子的分析表明

适合采用的Ar压强值在0.6~2.0 Pa。

Abstract

ZnO : Al (ZAO) thin films based on Al doped ZnO ceramic target were prepared on slide glass substrates by DC magnetron sputtering at room temperature. The effects of Al doping content and sputtering parameter on electrical and optical properties of ZAO thin films were investigated. The experimental results show that both the Al content and process parameters have a great influence on electrical property. When the Al content is 3%

the sputtering power is 100 W

the argon gas pressure is 1.5 Pa

ZAO thin films have a lowest resistivity of 1.410

-3

cm. The Al doping content and process parameters had a little influence on transmittance

and the average transmittances of ZAO thin films were from 86% to 90%

but the absorption edge has a blue shift with the increase of doping level and argon gas pressure. According to the analyses of FOM (figure of merit ) of ZAO

an argon pressure of 0.6~2.0 Pa is appropriate for ZAO thin films deposited by DC magnetron sputtering at room temperature.

关键词

Keywords

references

. Minami T. New n-type transparent conducting oxides [J]. MRS Bulletin, 2000, 25(8):38-44.

. Pearton S J, Norton D P, Ip K, et al. Recent advances in processing of ZnO [J]. J. Vac. Sci. Technol. B, 2004, 22(3):932-948.

. 杨兵初, 张丽, 马学龙,等. 掺锰氧化锌的结构和光学特性 [J]. 发光学报 ,2007,28(6):875-889.

. 徐小丽, 马书懿, 陈彦,等.氧分压对磁控溅射制备ZnO薄膜的结构及光学特性的影响[J]. 发光学报, 2007,28(5):730-735.

. 侯旭峰,荆海, 谷长栋,等. 高阻ITO基板上电化学沉积ZnO薄膜的研究 [J]. 液晶与显示 , 2007, 22(1):15-20.

. 张化福,袁玉珍,刘云燕. 柔性透明导电薄膜ZAO [J]. 液晶与显示 , 2008, 23(4):489-493.

. Kim H, Horwitz J S, Qadri S B, et al. Epitaxial growth of Al-doped ZnO thin films grown by pulsed laser deposition [J]. Thin Solid Films, 2002, 420-421:107-111.

. Lin S S, Huang J L, Sajgalik P. Effects of substrate temperature on the properties of heavily Al-doped ZnO films by simultaneous r.f. and d.c. magnetron sputtering [J]. Surface and Coatings Technology, 2005, 190: 39-47.

. Bai S N, Tseng T Y. Effect of alumina doping on structural, electrical, and optical properties of sputtered ZnO thin films [J]. Thin Solid Films, 2006, 515:872-875.

. Yoon M H, Lee S H, Park H L, et al. Solid solubility limits of Ga and Al in ZnO [J]. Mater. Sci. Lett., 2002, 21:1703-1704.

. Moss T S. The interpretation of the properties of indium antimonide [J]. Proc. Phys. Soc. B, 1954,67:775-782.

. Hu J, Gordan R G. Textured aluminum-doped zinc oxide thin films from atmospheric pressure chemical-vapor deposition [J]. J. Appl. Phys., 1992, 71(2): 880-890.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

氧氩比对Ta₂O₅栅介质薄膜晶体管电学性能的影响

磁控溅射法制备的MoO_x薄膜材料特性

热处理对磁控溅射法制备p-ITO(40 nm)薄膜特性的影响

载盘预处理对纯铝薄膜小丘生成的影响

大尺寸薄膜晶体管液晶显示器的一种条状显示不均的分析和改善研究