Process improvement of hybrid viewing-angle technology for energy-saving architecture on LCD

Shih-bin LIU; Zong-fei ZOU; Te-chen CHUNG; Xiao-jun GUO

doi:10.3788/YJYXS20193410.0952

您当前的位置：

首页 >

文章列表页 >

Process improvement of hybrid viewing-angle technology for energy-saving architecture on LCD

Materials and Devices | 更新时间：2020-08-12

- Process improvement of hybrid viewing-angle technology for energy-saving architecture on LCD
- Chinese Journal of Liquid Crystals and Displays Vol. 34, Issue 10, Pages: 952-958(2019)
- 作者机构：
  
  1.上海交通大学电子与通信工程学院电子工程系, 上海 200240
  2.昆山龙腾光电股份有限公司, 江苏昆山 215301
- 作者简介：
- 基金信息：
- DOI：10.3788/YJYXS20193410.0952
  CLC： TN141.9;TN27
- Received：08 June 2019，
  
  Accepted：22 August 2019，
  
  Published：05 October 2019
- 稿件说明：
移动端阅览
Shih-bin LIU, Zong-fei ZOU, Te-chen CHUNG, et al. Process improvement of hybrid viewing-angle technology for energy-saving architecture on LCD[J]. Chinese journal of liquid crystals and displays, 2019, 34(10): 952-958.
DOI：

Shih-bin LIU, Zong-fei ZOU, Te-chen CHUNG, et al. Process improvement of hybrid viewing-angle technology for energy-saving architecture on LCD[J]. Chinese journal of liquid crystals and displays, 2019, 34(10): 952-958. DOI： 10.3788/YJYXS20193410.0952.

摘要

为了让液晶分子受电场转动的效率增加，并减少钝化层对电场的耗损，本文对具宽窄视角可切换功能的液晶显示屏提出几种低功耗新设计。首先采用新型低电压液晶，在彩膜的制程顺序上做改动，并对TFT侧玻璃基板上的绝缘钝化层进行图案化减薄。减薄的设计方案有两种，一种是直接在钝化层上做部分减薄留下一些剩余厚度，另一种是用SiO

层取代钝化层的剩余厚度。设计变更后的透过率与电场特性使用了数值分析方法加以仿真。仿真结果表明：使用低电压液晶能使原有架构的饱和电压从5.4 V降低到4.3 V，结合减薄新设计可以分别再降低9.30%与13.95%。液晶饱和电压的降低表明节能新架构的液晶操作电压会比原有架构更低，进而面板上的整体功耗降低，达到了宽窄视角可切换低功耗液晶显示屏的需求。

Abstract

Some new designs with low power consumption of hybrid viewing-angle LCD are proposed in order to increase the rotating efficiency of liquid crystal molecules by tuning electric field and to reduce the loss of electric field from passivation layer. Firstly

a new type of liquid crystal with low voltage is used. Then the sequence of process on the color filter is changed

and the insulated passivation layer on the TFT side of glass substrate is patterned and thinned. There are two schemes for thinning. One is to make partial thinning on passivation layer directly

leaving some residual thickness. The other is to replace the residual thickness of passivation layer with SiO

layer. The characteristics of transmittance and electric field after changing design are simulated by the method of numerical analysis. These results of simulation show that the saturation voltage of this original architecture can be reduced from 5.4 V to 4.3 V by using low-voltage liquid crystal and the new design for thinning can further reduce the saturation voltage by 9.30% and 13.95% respectively. The decrease of saturation voltage on liquid crystal indicates that the operating voltage of liquid crystal on new architecture with energy-saving will be lower than that on the prior one

and then the overall power consumption of display panel will be reduced to satisfy the demand of hybrid viewing-angle LCD with low power consumption.

关键词

Keywords

references

许雅琴, 苏子芳, 钟德镇, 等.基于使用负性液晶的边沿场切换模式的局部残影分析[J].液晶与显示, 2015, 30(3):399-403.

XU Y Q, SU Z F, ZHONG S, et al . Analysis of FFS image sticking with negative liquid crystal[J]. Chinese Journal of Liquid Crystals and Displays , 2015, 30(3):399-403. (in Chinese)

朱梦青, 陆建钢.基于FFS架构实现宽窄视角切换[J].液晶与显示, 2018, 33(3):182-187.

ZHU M Q, LU J G. New viewing angle controllable with FFS-LCD[J]. Chinese Journal of Liquid Crystals and Displays , 2018, 33(3):182-187. (in Chinese)

李宏彦, 杨久霞, 吕艳英, 等. TFT-LCD用彩色滤光片[J].现代显示, 2005(6):41-44.

LI H Y, YANG J X, LV Y Y, et al . Color filter for TFT-LCD[J]. Advanced Display , 2005(6):41-44. (in Chinese)

YANG G Q, XIAO S L, SUN Y B. Insulation layer effect on electro-optic properties of fringe field switching liquid crystal display[J]. Molecular Crystals and Liquid Crystals , 2013, 582(1):15-20.

JANOTTA A, JANSSEN R, SCHMIDT M, et al . Doping and its efficiency in a -SiO x :H[J]. Physical Review B , 2004, 69(11):115206.

BACIOĜLU A, KODOLBAŞ A O, ÖKTÜ Ö. Deposition of highly photoconductive wide band gap a-SiO x :H thin films at a high temperature without H 2 -dilution[J]. Solar Energy Materials and Solar Cells , 2005, 89(1):49-59.

杨登科, 吴诗聪.液晶器件基础(原书第二版)[M].郭太良, 周雄图, 译.北京: 科学出版社, 2016.

YANG D K, WU S T. Fundamentals of Liquid Crystal Devices ( Second Edition )[M]. GUO T L, ZHOU X T, trans. Beijing: Science Press, 2016. (in Chinese)

OH-E M, KONDO K. Electro-optical characteristics and switching behavior of the in-plane switching mode[J]. Applied Physics Letters , 1995, 67(26):3895-3897.

LEE S H, LEE S L, KIM H Y. Electro-optic characteristics and switching principle of a nematic liquid crystal cell controlled by fringe-field switching[J]. Applied Physics Letters , 1998, 73(20):2881-2883.

CHIANG K H F, WU S T, CHEN S H. Fringing field effect of the liquid-crystal-on-silicon devices[J]. Japanese Journal of Applied Physics , 2002, 41(7A):4577-4585.

KIM D H, LIM Y J, KIM D E, et al . Past, present, and future of fringe-field switching-liquid crystal display[J]. Journal of Information Display , 2014, 15(2):99-106.

KIM W C, JEONG Y H, LEE S H. Electrooptic characteristics of a fringe-field driven hybrid aligned nematic liquid crystal cell using a liquid crystal with positive dielectric anisotropy[J] . Japanese Journal of Applied Physics , 2004, 43(2):637-641.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Review on driving method for low power consumption of TFT-based display screens

Design of high precision optical power meter based on MSP430

Indoor data acquisition and monitoring system based on Internet of things

Analysis and reduction research of liquid crystal loss in TFT-LCD industry

Pixel design for decreasing data load

Related Author

MIAO Zong-cheng

ZHANG Rui-yin

HE Ze-min

LIANG Peng-xia

Lei WANG

Ke ZHU

Jun WANG

Xin HE

Related Institution

BOE Technology Group Co.， Ltd.

School of Artificial Intelligence， Optics and Electronics （iOPEN）， Northwestern Polytechnical University

Technological Institute of Materials & Energy Science （TIMES）， School of Electronic Information， Xijing University

Changchun Institute of Optics, Fine Mechanics and Physics, Chinese Academy of Sciences

Suzhou University of Science and Technology

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China 130033 Postal code：130033
Tel：0431-86176059 Email：yjxs@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰