Effect of thickness of a-Si remain on TFT characteristics

Mao-kun TIAN; Zhong-hao HUANG; Wei CHEN; Kai WANG; Si-jiang WANG; Rui WANG; Xiao-nan DONG; Yong-liang ZHAO; Tai-ye MIN; Jian-feng YUAN; Lei-lai SUN

doi:10.3788/YJYXS20193407.0646

您当前的位置：

首页 >

文章列表页 >

Effect of thickness of a-Si remain on TFT characteristics

Materials and Devices | 更新时间：2020-07-05

- Effect of thickness of a-Si remain on TFT characteristics
- Chinese Journal of Liquid Crystals and Displays Vol. 34, Issue 7, Pages: 646-651(2019)
- 作者机构：
  
  重庆京东方光电科技有限公司, 重庆 400700
- 作者简介：
- 基金信息：
- DOI：10.3788/YJYXS20193407.0646
  CLC： TN27
- Received：25 December 2018，
  
  Accepted：25 April 2019，
  
  Published：05 July 2019
- 稿件说明：
移动端阅览
Mao-kun TIAN, Zhong-hao HUANG, Wei CHEN, et al. Effect of thickness of a-Si remain on TFT characteristics[J]. Chinese journal of liquid crystals and displays, 2019, 34(7): 646-651.
DOI：

Mao-kun TIAN, Zhong-hao HUANG, Wei CHEN, et al. Effect of thickness of a-Si remain on TFT characteristics[J]. Chinese journal of liquid crystals and displays, 2019, 34(7): 646-651. DOI： 10.3788/YJYXS20193407.0646.

摘要

本文通过电学特性测试设备在黑暗（Dark）和光照（Photo）两种测试环境下，研究了沟道不同a-Si剩余厚度对TFT电学特性的影响。通过调整刻蚀时间改变沟道内a-Si剩余厚度，找出电学特性稳定区域以及突变的临界点。实验结果表明：在黑暗（Dark）环境下a-Si剩余厚度在30%~48%之间时，TFT器件的电学特性比较稳定，波动较小；而剩余厚度少于30%时，TFT特性变差，工作电流变小，开启电压变大，电子迁移率变小；在光照环境下主要考虑漏电流的影响，在a-Si剩余厚度43%以内时，光照

off

相对较低（小于Spec 20 pA），同时变化趋势较缓；而剩余厚度大于43%时，光照

off

增加25%，同时变化趋势陡峭。综合黑暗和光照测试环境，在其他条件不变的情况下，a-Si剩余厚度在30%~43%之间时TFT的电学特性较好，同时相对稳定。

Abstract

The effects of different a-Si remain thickness of channel on the electrical properties of TFT were studied under dark and photo test environments. The thickness of a-Si remain in channel was changed by adjusting the etching time. Futhermore

the stable region and the critical point of radical change of electrical were found through this experiment. The experimental results show that the electrical characteristics of TFT devices are relatively stable and fluctuate slightly when the thickness of a-Si remain is between 30% and 48% in dark environment. When the remaining thickness is less than 30%

the TFT characteristics become worse

becomes smaller

becomes larger

and the mobility decreases consequently. Unlike dark condition

off

is the chief consideration under photo circumstance. When the thickness of a-Si remain is less than 43%

photo

off

is relatively low (less than spec 20 pA)

and the trend of change is relatively slow. But when the residual thickness is more than 43%

photo

off

increases by 25%

and the trend of change is steep. In conclusion

when the thickness of a-Si remain is between 30% and 43%

the electrical characteristics of TFT are better and relatively stable regardless of test conditions.

关键词

Keywords

references

IBARAKI N, FUKUDA K, TAKATA H. The effect of interface states on amorphous-silicon transistors[J]. IEEE Transactions on Electron Devices , 1989, 36(12): 2971-2972.

宋跃, 邹雪城.a-Si TFT亚阈特征参数与有源层的厚度效应[J].固体电子学研究与进展, 2004, 24(1):20-25.

SONG Y, ZOU X C. The subthreshold characterization parameter and active layer thickness effect over a-Si TFT[J]. Research & Progress of SSE , 2004, 24(1): 20-25. (in Chinese)

李田生, 谢振宇, 李婧, 等.有源层刻蚀工艺优化对TFT-LCD品质的影响[J].液晶与显示, 2013, 28(5):720-725.

LIT S, XIE Z Y, LI J, et al . Effect of active layer etch conditions improvement on TFT-LCD quality[J]. Chinese Journal of Liquid Crystals and Displays , 2013, 28(5): 720-725. (in Chinese)

张少强, 徐重阳, 邹雪城, 等.薄有源层非晶硅薄膜晶体管特性的研究[J].电子学报, 1997, 25(2):53-56.

ZHANG S Q, XU C Y, ZOU X C, et al . The study of the characteristics of a-Si:H TFT with thin active layer structure[J]. Acta Electronica Sinica , 1997, 25(2): 53-56. (in Chinese)

闫方亮, 沈世妃, 侯智, 等.a-Si厚度对TFT开关特性的影响[J].现代显示, 2011, 22(7):23-28.

YAN F L, SHEN S F, HOU Z, et al . Effect of a-silicon thickness on TFT characteristic[J]. Advanced Display , 2011, 22(7): 23-28. (in Chinese)

马群刚.TFT-LCD原理与设计[M].北京:电子工业出版社, 2011.

MA Q G. Principle and Design of TFT-LCD [M]. Beijing: Publishing House of Electronics Industry, 2011. (in Chinese)

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

TFT character of Al electrode in TFT-LCD

Influence of ITO contamination of TFT gate insulation & a-Si layers on electrical characteristics

Improvement of TFT Electrical Characteristics by Optimization of Gate Insulating and Active Layer Deposition

Related Author

Yan-qiang WANG

Jia-xiang ZHANG

Jing-peng LI

Liang-jie LI

Kun LIU

Qi WANG

Jie ZHANG

Liang WANG

Related Institution

Beijing BOE Optoelectronics Technology Co., Ltd.

Process Development Department, BOE Display Technology Co. Ltd.

Beijing BOE Optoelectronics Technology Co., Ltd, Beijing 100176, China

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China 130033 Postal code：130033
Tel：0431-86176059 Email：yjxs@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰