Testing uniformity of spacers in LCD with the way of polarization interference

FAN Ying-juan; YUAN Tao-li; ZHANG Mai-li

doi:10.3788/YJYXS20153003.0416

您当前的位置：

首页 >

文章列表页 >

Testing uniformity of spacers in LCD with the way of polarization interference

Device Physics & Device Technology | 更新时间：2020-08-12

- Testing uniformity of spacers in LCD with the way of polarization interference
- Chinese Journal of Liquid Crystals and Displays Vol. 30, Issue 3, Pages: 416-420(2015)
- 作者机构：
  
  陕西科技大学理学院,陕西西安,710021
- 作者简介：
- 基金信息：
- DOI：10.3788/YJYXS20153003.0416
  CLC： TN141.9
- Received：09 September 2014，
  
  Revised：26 October 2014，
  
  Published：05 June 2015
- 稿件说明：
移动端阅览
范应娟, 袁桃利, 张麦丽. 偏光干涉法检测LCD间隔子的均匀性[J]. 液晶与显示, 2015,30(3): 416-420

FAN Ying-juan, YUAN Tao-li, ZHANG Mai-li. Testing uniformity of spacers in LCD with the way of polarization interference[J]. , 2015,30(3): 416-420
范应娟, 袁桃利, 张麦丽. 偏光干涉法检测LCD间隔子的均匀性[J]. 液晶与显示, 2015,30(3): 416-420 DOI： 10.3788/YJYXS20153003.0416.

FAN Ying-juan, YUAN Tao-li, ZHANG Mai-li. Testing uniformity of spacers in LCD with the way of polarization interference[J]. , 2015,30(3): 416-420 DOI： 10.3788/YJYXS20153003.0416.

摘要

由于液晶显示器中间隔子的均匀性影响着对比度、色调变化等性能

因此

本文对液晶显示屏间隔子均匀性的检测方法进行了研究.首先分别利用干喷和湿喷法制备了对应的液晶盒

然后采用偏光显微镜研究了所制备液晶显示屏间隔子的分布特性.研究发现

正常情况下

液晶盒内间隔子最小距离接近20 m

最大距离超过100 m;间隔子分布不良的主要缺陷为间隔子团聚;在实验室条件下

干喷法间隔子团聚比较严重

湿喷法基本上无此现象.所以

利用偏光干涉法

通过调节偏光显微镜上下偏光片的相对角度

可以在不破坏液晶显示屏的前提下直接观察到其内部的间隔子及间隔子的分布情况.文中还分析了利用偏光干涉检验间隔子均匀性的原理.

Abstract

In liquid crystal display

the uniformity of spacers influences contrast degree and color tone change

et al. Thus

the test method of uniformity of spacers in LCD is researched in this paper. Firstly

the liquid crystal cells are made by using dry spray method and wet spray method

then the distribution character of spacers is studied by using the polarizing microscope. It is found that

in normal case

the least distance of spacers in LCD is close to 20 m and the largest distance exceeds 100 m. The cluster of spacers is the main defect which leads to badly distribute. Under laboratory conditions

the cluster of spacers is more serious by using dry spray method but this phenomenon doesn't exist basically by using wet spray method. Therefore

by using the way of polarization interference and through adjusting the relative angle of up and down polarized plates of the polarizing microscope

the spacers and distribution of spacers can be directly observed without destroying the LCD. The principle of the spacers uniformity tested by using polarization interference is also analyzed.

关键词

Keywords

references

高媛媛, 郑远洋, 杜渭松, 等. 含氟液晶的性能、应用于合成进展 [J]. 液晶与显示, 2014, 29(2): 159-171. Gao A A, Zheng Y Y, Du W S,et al. Fluorinated liquid crystal properties, application and synthetic progress [J]. Chinese Journal of Liquid Crystal and Displays, 2014, 29(2): 159-171. (in Chinese)[2] Waclawik E R, Ford M J, Hale P S, et al. Liquid-crystal displays: fabrication and measurement of a twisted nematic liquid-crystal cell [J]. Journal of Chemical Education, 2004, 81(6): 854-858.[3] 徐长远. STN-LCD液晶显示器定向层摩擦工序的静电研究[J]. 现代显示, 2006, 69(10):49-52. Xu C Y. The electrostatio study in rubbing process of STN-LCD [J]. Advanced Display, 2006, 69(10):49-52. (in Chinese)[4] 荆海. IPS液晶显示模式的研究[D]. 长春:中国科学院长春光学精密机械与物理研究所, 2000. Jin H. Study on the mode of IPS liquid crystal display [D]. Changchun: Changchun Institute of Optics, Fine Mechanics and Physics, Chinese Academy of Sciences, 2000. (in Chinese)[5] 费民权, 费悦. MVA模式TFT-LCD用彩色滤光片制程解析[J]. 现代显示, 2009, 98:28-33. Fei M Q, Fei Y. The process analysis of MVA mode TFT-LCD color filter [J].Advanced Display, 2009, 98:28-33. (in Chinese)[6] 张方辉, 张麦丽, 许淑惠. 液晶显示器用玻璃衬垫的探讨[J]. 玻璃与搪瓷, 2005, 33(2):34-51. Zhang F H, Zhang M L, Xu S H. Research on LCD-Glass spacers [J]. Glass & Enamel, 2005, 33(2): 34-51. (in Chinese)[7] Jinook K, Tae-joon S, Ju H K, et al. Formation of the overcoat layer and column spacer for TFT-LCD using capillary force lithography [J]. Displays, 2010, 31(2): 82-86.[8] 程石, 王涛, 张敏, 等. TFT-LCD中隔垫物密度与Push Mura和低温气泡的关系[J]. 液晶与显示, 2011, 26(5): 604-607. Cheng S, Wang T, Zhang M, et al. Relationship of spacer density with push mura and cold bubble in TFT-LCD [J]. Chinese Journal of Liquid Crystal and Displays, 2011, 26(5): 604-607. (in Chinese)[9] 张麦丽, 王秀峰, 张方辉, 等. 液晶显示器用隔垫物的研究现状与最新进展[J]. 液晶与显示, 2004, 19(1):24-29. Zhang M L, Wang X F, Zhang F H, et al. Status and future prospects of LCD-spacer [J]. Chinese Journal of Liquid Crystal and Displays, 2004,19(1): 24-29. (in Chinese)[10] 范志新, 陈久琳, 章红林. 液晶显示器用衬垫料的扫描电镜图像[J]. 光学技术, 2002, 28(2):189-190. Fan Z X, Chen J L, Zhang H L. SEM photograph of LCD-spacer [J]. Optical Technique, 2002, 28(2): 189-190. (in Chinese)

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Low coherence carrier frequency interference method for measurement of the liquid crystal cell surface

Phase field method in capacitance characteristics of nematic liquid crystals with different initial alignments

Uniform dimming technologies for large-area OLED module

Design of High Uniformity LED Backlight

Design of LCD Backlight Module Based on Plano-Concave Lens Array

Related Author

Wen-hua ZHU

Zheng-yu ZHANG

Chen-hui HU

Lei CHEN

Guang YANG

Zhi-dong ZHOU

Shu-kai WANG

XU Sheng

Related Institution

Advanced Launching Co-innovation Center, Nanjing University of Science and Technology

School of Electronic and Optical Engineering, Nanjing University of Science and Technology

Fujian Key Laboratory of Advanced Materials, College of Materials, Xiamen University

College of Physics and Information Engineering of Fuzhou University

Department of Physics, Shanghai JiaoTong University

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China 130033 Postal code：130033
Tel：0431-86176059 Email：yjxs@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰