Preparation of High-Performance Organic Thin-Film Transistor Through Surface Modification

LIN Guang-qing; LI Peng; WANG Ming-hui; FENG Xiang; ZHANG Jun; XIONG Xian-feng; QIU Long-z

doi:10.3788/YJYXS20132804.0490

您当前的位置：

首页 >

文章列表页 >

Preparation of High-Performance Organic Thin-Film Transistor Through Surface Modification

Material Physics & Chemistry | 更新时间：2020-08-12

- Preparation of High-Performance Organic Thin-Film Transistor Through Surface Modification
- Chinese Journal of Liquid Crystals and Displays Vol. 28, Issue 4, Pages: 490-494(2013)
- 作者机构：
  
  1. 特种显示技术教育部重点实验室,特种显示技术国家工程实验室,现代显示技术省部共建国家重点实验室培育基地, 合肥工业大学光电技术研究院,安徽合肥,230009
  2. 合肥工业大学化学工程学院,安徽合肥,230009
  3. 合肥工业大学仪器科学与光电工程学院,安徽合肥,230009
- 作者简介：
- 基金信息：
- DOI：10.3788/YJYXS20132804.0490
  CLC： TN321+.52
- Received：06 March 2013，
  
  Revised：05 April 2013，
  
  Published：15 August 2013
- 稿件说明：
移动端阅览
林广庆, 李鹏, 王明晖, 冯翔, 张俊, 熊贤风, 邱龙臻, 吕国强. 表面修饰制备高性能薄膜晶体管[J]. 液晶与显示, 2013,28(4): 490-494

LIN Guang-qing, LI Peng, WANG Ming-hui, FENG Xiang, ZHANG Jun, XIONG Xian-feng, QIU Long-zhen, LV Guo-qiang. Preparation of High-Performance Organic Thin-Film Transistor Through Surface Modification[J]. , 2013,28(4): 490-494
林广庆, 李鹏, 王明晖, 冯翔, 张俊, 熊贤风, 邱龙臻, 吕国强. 表面修饰制备高性能薄膜晶体管[J]. 液晶与显示, 2013,28(4): 490-494 DOI： 10.3788/YJYXS20132804.0490.

LIN Guang-qing, LI Peng, WANG Ming-hui, FENG Xiang, ZHANG Jun, XIONG Xian-feng, QIU Long-zhen, LV Guo-qiang. Preparation of High-Performance Organic Thin-Film Transistor Through Surface Modification[J]. , 2013,28(4): 490-494 DOI： 10.3788/YJYXS20132804.0490.

摘要

应用聚苯乙烯/氯硅烷复合材料作为栅绝缘层的界面修饰层制备了高性能的并五苯场效应晶体管。原子力显微镜观察发现

界面修饰对并五苯半导体薄膜的生长形貌产生了很大影响。在空白二氧化硅上沉积的并五苯晶粒尺寸都小于150 nm

而在修饰过后二氧化硅的表面生长的并五苯晶粒尺寸多在200~400 nm。大的晶粒尺寸能够减小晶粒间的界面

从而有效提高电学性能。表面改性的并五苯场效应晶体管的关态电流约为10

-10

电流的开关比超过10

最大场效应迁移率约可达1.23 cm

-1

而未处理的晶体管的场效应迁移率仅有0.011 8 cm

-1

。

Abstract

High-performance pentacene organic thin film Transistor (OTFT) with interface modification layer of polystyrene/chlorosilane composite material was developed. The AFM images show that the growth morphology of pentacene semiconductor film was affected by interface modification. The pentacene grains grown on modified SiO

substrates with dimensions in the range of 200~400 nm are larger than those grown on bare SiO

substrates which have sizes less than 150 nm. Large particle size can reduce intergranular interface so as to improve the electrical performance. The output and transfer curve

on/off current ratio

threshold voltage and field-effect mobility of the device were obtained by electric measurements. The transfer curve showed an on/off current ratio exceeding 10

with the off-current of about 10

-10

A. The device with interface modification has a maximum field-effect mobility of up to 1.23 cm

-1

compared to the 0.0118 cm

-1

of OTFT on bare SiO

substrate.

关键词

Keywords

references

Crone B, Dodabalapur A, Lin Y Y, et al. Large-scale complementary integrated circuits based on organic transistors [J]. Nature, 2000, 403 (6769):521-523.[2] Klauk H, Zschieschang U, Pflaum J, et al. Ultralow-power organic complementary circuits [J]. Nature, 2007, 445 (7129):745-748.[3] Sekitani T, Noguchi Y, Hata K, et al. A rubberlike stretchable active matrix using elastic conductors [J]. Science, 2008, 321 (5895):1468-1472.[4] DeLongchamp D M, Kline R J, Lin E K, et al. High carrier mobility polythiophene thin films:structure determination by experiment and theory [J]. Adv. Mater., 2007, 19 (6):833-837.[5] Yan H, Chen Z H, Zheng Y, et al. A high-mobility electron-transporting polymer for printed transistors [J]. Nature, 2009, 457 (7230):679-686.[6] Cho J H, Lee J, Xia Y, et al. Printable ion-gel gate dielectrics for low-voltage polymer thin-film transistors on plastic [J]. Nat. Mater., 2008, 7 (11):900-906.[7] Tsao H N, Cho D M, Park I, et al. Ultrahigh mobility in polymer field-effect transistors by design [J]. J. Am. Chem. Soc., 2011, 133 (8):2605-2612.[8] Sun X N, Di C A, Liu Y Q. Engineering of the dielectric-semiconductor interface in organic field-effect transistors [J]. J. Mater. Chem., 2010, 20: 2599-2611.[9] Smith J, Hamilton R, McCulloch I, et al. Solution-processed organic transistors based on semiconducting blends [J]. J. Mater. Chem., 2010, 20: 2562-2574.[10] 汪梅林,张其国,郑永亮,等. 有机薄膜晶体管阵列面向电子纸像素设计 [J]. 液晶与显示, 2012,27(1):38-42.[11] 陈世琴,陈梦婕,邱龙臻. 石墨烯电极有机薄膜晶体管研究 [J]. 液晶与显示, 2012,27(5):595-598.[12] 冯魏良,黄培. 柔性显示衬底的研究及进展 [J]. 液晶与显示, 2012,27(5):599-607.[13] Lin Y Y, Gundlach D J, Nelson S F, et al. Stacked pentacene layer organic thin-film transistors with improved characteristics [J]. IEEE Electron Device Letters, 1997, 19(12): 606-608.[14] Klauk Hagen, Halik Marcus, Zschieschang Ute, et al.High mobility polymer gate dielectric pentacene thin film transistors [J]. J. Appl. Phys., 2002, 92(9): 5259-5263.[15] Yusaku Kato, Shingo Iba, Ryohei Teramoto, et al.High mobility of pentacene field-effect transistors with polyimide gate dielectric layers [J]. Appl. Phys. Lett., 2004, 84(19): 3789-3791.[16] Yoneya N, Noda M, Hirai N, et al. Reduction of contact resistance in pentacene thin-film transistors by direct carrier injection into a-few-molecular-layer channel [J]. Appl. Phys. Lett., 2004,85(20):4663-4665.[17] Yang S Y,Shin K,Park C E.The effect of gate-dielectric surface energy on pentacene morphology and organic field-effect transistor characteristics [J]. Adv. Funct. Mater., 2005, 15(11):1806-1814.[18] Choi D, Ahn B, Kim S H, et al. High-performance triisopropylsilylethynyl pentacene transistors via spin coating with a crystallization-assisting layer [J]. ACS Appl. Mater. Interfaces, 2012, 4(1):117-122.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Wetting/Dewetting Patterned TIPS-Pentacene Organic Thin-Film Transistor

Organic Thin-Film Transistor Based on Graphene Electrodes

Transparent organic memory based on quantum dots floating gate

High sensitivity organic transistor nitrogen dioxide sensor based on three component conjugated polymer

Impact of plasma treatment of dielectric layer on synaptic performance of organic thin film transistors

Related Author

QIU Long-zhen

LI Man-fei

ZHANG Jun

LIN Guang-qing

FENG Xiang

QIU Long-zhen

CHEN Meng-jie

CHEN Shi-qin

Related Institution

Key Lab of Special Display Technology, Ministry of Education, National Engineering Lab of Special Display Technology, National Key Lab of Advanced Display Technology, Academy of Opto-Electronic Technology, Hefei University

Research Center for Microelectronics Technology， Fujian University of Technology

National Engineering Lab of Special Display Technology， Anhui Province Key Laboratory of Measuring Theory and Precision Instrument， Academy of Opto-Electronic Technology， Hefei University of Technology

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China 130033 Postal code：130033
Tel：0431-86176059 Email：yjxs@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰