Application of optical alignment technology in TFT-LCD

Guo-jing MA; Dan WANG; Shun-sha LU; Meng-meng LU; Qing-sen GUO; Yong-zhi SONG; Wei-tao CHEN

doi:10.37188/CJLCD.2020-0324

您当前的位置：

首页 >

文章列表页 >

Application of optical alignment technology in TFT-LCD

Display Technologyand Applications | 更新时间：2021-04-28

- Application of optical alignment technology in TFT-LCD
- Chinese Journal of Liquid Crystals and Displays Vol. 36, Issue 5, Pages: 694-698(2021)
- 作者机构：
  
  北京京东方显示技术有限公司, 北京 100176
- 作者简介：
- 基金信息：
  
  Beijing Municipal Science & Technology Commission: Application Technology Research and Development Projects of Capital Science and Technology Leading Talents Training Project(No.)(201807)
- DOI：10.37188/CJLCD.2020-0324
  CLC： TN27
- Received：04 December 2020，
  
  Revised：12 January 2021，
  
  Published：2021-05
- 稿件说明：
移动端阅览
Guo-jing MA, Dan WANG, Shun-sha LU, et al. Application of optical alignment technology in TFT-LCD[J]. Chinese journal of liquid crystals and displays, 2021, 36(5): 694-698.
DOI：

Guo-jing MA, Dan WANG, Shun-sha LU, et al. Application of optical alignment technology in TFT-LCD[J]. Chinese journal of liquid crystals and displays, 2021, 36(5): 694-698. DOI： 10.37188/CJLCD.2020-0324.

摘要

本文重点研究了降解型光控取向技术的制作工艺及其对产品性能的影响。通过分析不同光配向工艺参数下配向膜各向异性的数值可知，随着UV光光积量的增大和二次固化时间的延长，配向膜的各向异性值都有先升高后降低的趋势。测试材料在550 mJ/cm

和30 min的条件下，配向能力最优；配向膜材料二次固化温度在250 ℃以内时对配向性的影响是随温度升高，配向膜的各向异性值有直线上升趋势。通过改变光配向的工艺条件测试TFT特性的变化，发现完整的光配向工艺对TFT特性无明显影响。本文还分析了光配向形成的配向膜的低预倾角(约0.2°)对产品性能的影响，从结果可知，低预倾角下产品的对比度可达到1 500以上，与摩擦型产品对比提升了约50%。

Abstract

The degradable optical alignment technology and its main effects on TFT-LCD are studied. The anisotropy of PI shows a trend from increasing to decreasing as the exposure dose increases and the main curing time extends. The anisotropy of PI

which is a common representation of the alignment ability of PI

performs best at 550 mJ/cm

ultraviolet treatment and 30 min curing time. In addition

the anisotropy of PI keeps increasing as the main curing temperature increases from 230 ℃ to 250 ℃. Results also demonstrate that the complete optical alignment has no obvious effect on the electrical properties of TFTs. Compared to rubbing process

optical alignment shows huge advantages of contract ratio. The contract ratio of optical alignment product is about 1 500

approximately 50% higher than that of rubbing product

due to the low pre-title angle (about 0.2°).

关键词

Keywords

references

马群刚 . TFT-LCD原理与设计 , : 北京电子工业出版社 , 2011 .

Q G MA . Principle and Design of TFT-LCD , : Beijing Publishing House of Electronics Industry , 2011 .

杨宗顺 , 杨夏梅 , 熊奇 , 等 . 摩擦工艺不良的探究 . 液晶与显示 , 2019 . 34 ( 11 ): 1073 - 1078 . http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193411.1073 http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193411.1073 .

Z S YANG , X M YANG , Q XIONG , 等 . Research and solution of defects in rubbing process . Chinese Journal of Liquid Crystals and Displays , 2019 . 34 ( 11 ): 1073 - 1078 . http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193411.1073 http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193411.1073 .

周波 , 王祺 , 宋勇志 , 等 . TFT-LCD中液晶取向异常亮点机理研究及改善 . 液晶与显示 , 2020 . 35 ( 2 ): 115 - 121 . http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20203502.0115 http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20203502.0115 .

B ZHOU , Q WANG , Y Z SONG , 等 . Research and improvement of bright dot caused by abnormal liquid crystal alignment on TFT-LCD . Chinese Journal of Liquid Crystals and Displays , 2020 . 35 ( 2 ): 115 - 121 . http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20203502.0115 http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20203502.0115 .

杨德波 , 钟野 , 毕芳 , 等 . Mobile产品异物产生机理及改善研究 . 液晶与显示 , 2019 . 34 ( 8 ): 748 - 754 . http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193408.0748 http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193408.0748 .

D B YANG , Y ZHONG , F BI , 等 . Reduction and mechanism of particles on mobile products . Chinese Journal of Liquid Crystals and Displays , 2019 . 34 ( 8 ): 748 - 754 . http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193408.0748 http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193408.0748 .

栗芳芳 , 汪弋 , 陆相晚 , 等 . 摩擦配向工艺对HADS产品像素漏光的影响分析 . 液晶与显示 , 2019 . 34 ( 3 ): 241 - 244 . http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193403.0241 http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193403.0241 .

F F LI , Y WANG , X W LU , 等 . Analysis of the effect of rubbing process on pixel leakage of HADS . Chinese Journal of Liquid Crystals and Displays , 2019 . 34 ( 3 ): 241 - 244 . http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193403.0241 http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20193403.0241 .

李继军 , 聂晓梦 , 李根生 , 等 . 平板显示技术比较及研究进展 . 中国光学 , 2018 . 11 ( 5 ): 695 - 710 . https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGA201805001.htm https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGA201805001.htm .

J J LI , X M NIE , G S LI , 等 . Comparison and research progress of flat panel display technology . Chinese Optics , 2018 . 11 ( 5 ): 695 - 710 . https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGA201805001.htm https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGA201805001.htm .

廖燕平 , 宋勇志 , 邵喜斌 , 等 . 薄膜晶体管液晶显示器显示原理与设计 , : 北京电子工业出版社 , 2016 .

Y P LIAO , Y Z SONG , X B SHAO , 等 . Thin Film Transistor Liquid Crystal Display , : Beijing Publishing House of Electronics Industry , 2016 .

张春华 , 杨正华 , 丁孟贤 . 聚酰亚胺光控取向膜的研究现状 . 高分子通报 , 2002 . ( 6 ): 15 - 23 . https://www.cnki.com.cn/Article/CJFDTOTAL-GFZT200206002.htm https://www.cnki.com.cn/Article/CJFDTOTAL-GFZT200206002.htm .

C H ZHANG , Z H YANG , M X DING . Recent development in photoalignment polyimide films . Polymer Bulletin , 2002 . ( 6 ): 15 - 23 . https://www.cnki.com.cn/Article/CJFDTOTAL-GFZT200206002.htm https://www.cnki.com.cn/Article/CJFDTOTAL-GFZT200206002.htm .

张万隆 , SRIVASTAVA A , ROGACH A , 等 . 半导体量子棒的光控取向技术进展 . 液晶与显示 , 2020 . 35 ( 5 ): 409 - 421 . http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20203505.0409 http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20203505.0409 .

W L ZHANG , A SRIVASTAVA , A ROGACH , 等 . Progress in photo-induced semiconductor quantum rods alignment . Chinese Journal of Liquid Crystals and Displays , 2020 . 35 ( 5 ): 409 - 421 . http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20203505.0409 http://cjlcd.lightpublishing.cn/thesisDetails#10.3788/YJYXS20203505.0409 .

J M GEARY , J W GOODBY , A R KMETZ , 等 . The mechanism of polymer alignment of liquid-crystal materials . Journal of Applied Physics , 1987 . 62 ( 10 ): 4100 - 4108 . DOI: 10.1063/1.339124 http://doi.org/10.1063/1.339124 .

O YAROSHCHUK , Y REZNIKOV . Photoalignment of liquid crystals: basics and current trends . Journal of Materials Chemistry , 2012 . 22 ( 2 ): 286 - 300 . http://www.tandfonline.com/servlet/linkout?suffix=CIT0004&dbid=16&doi=10.1080%2F02678292.2018.1429027&key=10.1039%2FC1JM13485J http://www.tandfonline.com/servlet/linkout?suffix=CIT0004&dbid=16&doi=10.1080%2F02678292.2018.1429027&key=10.1039%2FC1JM13485J .

洪一凡 , 臧金亮 , 刘颖 , 等 . 偏光全息研究历程与展望 . 中国光学 , 2017 . 10 ( 5 ): 588 - 602 . https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGA201705006.htm https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGA201705006.htm .

Y F HONG , J L ZANG , Y LIU , 等 . Review and prospect of polarization holography . Chinese Optics , 2017 . 10 ( 5 ): 588 - 602 . https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGA201705006.htm https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGA201705006.htm .

梁兆颜 , 闫石 , 马凯 , 等 . 液晶显示用取向材料聚甲基丙烯酸肉桂酰氧基乙酯的光控取向研究 . 发光学报 , 1999 . 20 ( 3 ): 217 - 223 . https://www.cnki.com.cn/Article/CJFDTOTAL-FGXB199903005.htm https://www.cnki.com.cn/Article/CJFDTOTAL-FGXB199903005.htm .

Z Y LIANG , S YAN , K MA , 等 . Study on photo alignment of cinnamate material 2(cinnamoyloxy)ethyl methacrylate for LCD using LPP method by UV light . Chinese Journal of Luminescence , 1999 . 20 ( 3 ): 217 - 223 . https://www.cnki.com.cn/Article/CJFDTOTAL-FGXB199903005.htm https://www.cnki.com.cn/Article/CJFDTOTAL-FGXB199903005.htm .

Views

534

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

New alignment material for TFT-LCD

Research progress on liquid crystal optical devices with viewing angle control characteristics

Relationship of field components in the liquid crystal optical waveguide eigenmode

Reduction and mechanism of particles on mobile products

Related Author

Guo-jing MA

Dan WANG

Shun-sha Lu

Meng-meng Lu

Qing-sen Guo

Yong-zhi Song

Wei-tao Chen

Jian-yun XIE

Related Institution

Beijing BOE Optoelectronics Technology Co. Ltd.

Ordos Yuansheng Optoelectronics Co.Ltd

College of Materials Science and Engineering， Beijing University of Chemical Technology

Key Laboratory of Carbon Fiber and Functional Polymers， Ministry of Education， Beijing University of Chemical Technology

School of Electronic Information Engineering, China West Normal University, Nanchong

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China 130033 Postal code：130033
Tel：0431-86176059 Email：yjxs@ciomp.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰